|本期目录/Table of Contents|

[1]丁金画,纵岗,王璇,等.药卷位置对边坡光面爆破效果影响研究[J].中国安全生产科学技术,2020,16(5):102-107.[doi:10.11731/j.issn.1673-193x.2020.05.016]
　DING Jinhua,ZONG Gang,WANG Xuan,et al.Study on influence of cartridge position on smooth blasting effect of slope[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2020,16(5):102-107.[doi:10.11731/j.issn.1673-193x.2020.05.016]
点击复制

药卷位置对边坡光面爆破效果影响研究
分享到：

《中国安全生产科学技术》[ISSN:1673-193X/CN:11-5335/TB]

卷:
16
期数:
2020年5期
页码:
102-107
栏目:
职业安全卫生管理与技术
出版日期:
2020-05-30

文章信息/Info

Title:
Study on influence of cartridge position on smooth blasting effect of slope
文章编号:
1673-193X(2020)-05-0102-06
作者:
丁金画; 纵岗; 王璇; 李莉; 顾聪; 刘娟
（1.盐城工业职业技术学院，江苏 盐城 224005；
2.江苏科技大学 土木工程与建筑学院，江苏 镇江212003；
3.东北大学 资源与土木工程学院，辽宁 沈阳 110819； 4.安徽建鑫工程咨询有限公司，安徽 宿州 234000）
Author(s):
DING Jinhua;  ZONG Gang;  WANG Xuan;  LI Li;  GU Cong;  LIU Juan
（1.Yancheng Polytechnic College,Yancheng Jiangsu 224005,China；
2.School of Civil Engineering and Architecture,Jiangsu University of Science and Technology,Zhenjiang Jiangsu 212003,China；
3.School of Resource and Civil Engineering,Northestern Unive
关键词:
边坡; 光面爆破; 药卷位置; 模拟; 现场试验
Keywords:
slope;  smooth blasting;  cartridge position;  simulation;  field test
分类号:
X936
DOI:
10.11731/j.issn.1673-193x.2020.05.016
文献标志码:
A
摘要:
为了进一步探究药卷位置对边坡光面爆破效果的影响，在LS-DYNA构建孔径90 mm、药卷直径32 mm的同心不耦合装药和偏心不耦合装药模型，分析2种装药形式的孔壁压力及损伤展布情况，并基于此提出改进偏心不耦合装药，通过现场光面爆破试验验证改进偏心不耦合装药应用效果。研究结果表明：同心不耦合装药孔壁各测点压力峰值基本相同，炮孔周围相同爆心距处的损伤等级基本一致；偏心不耦合装药孔壁各测点压力峰值从炮孔底部到炮孔顶部逐渐减小，下方耦合侧岩体的损伤等级与损伤范围明显优于上方不耦合侧岩体；原有偏心不耦合装药会导致边坡预留岩体产生过度破坏，采用改进偏心不耦合装药能避免边坡预留岩体的过度破坏，形成平整光滑的爆后轮廓面。
Abstract:
To further study the influence of cartridge position on the smooth blasting effect of slope,the models of concentric decouple charge and eccentric decouple charge with the bore diameter of 90 mm and cartridge diameter of 32 mm were established by using LS-DYNA.The pressure on the hole wall and damage distribution of two kinds of charge form were analyzed,and on this basis,the improved eccentric decouple charge was proposed,then its application effect was verified through the field tests of smooth blasting.The results showed that the pressure peaks of each measuring point on the hole wall with the concentric decouple charge were basically the same,and the damage level at the positions with the same blast center distance around the hole was basically the same.The pressure peaks of each measuring point on the hole wall with the eccentric decouple charge hole decreased gradually from the bottom of the blast hole to the top of the blast hole,and the damage level and damage range of the rock mass on the couple side below were obviously better than those on the decouple side above.The original eccentric decouple charge could cause the excessive damage to the reserved rock mass of the slope.The improved eccentric decouple charge could avoid the excessive damage of the reserved rock mass of the slope,and form a flat and smooth contour surface after the blasting.

参考文献/References:

［1］程贵海,张勤彬,王毅,等.光面爆破在边坡开挖中的应用研究［J］.化工矿物与加工,2019,48(2):11-16. CHENG Guihai,ZHANG Qinbin,WANG Yi,et al.Application and numerical simulation of smooth blasting in slope excavation［J］.Industrial Minerals & Processing,2019,48(2):11-16.
［2］高文学,刘宏宇,刘洪洋,等.爆破开挖对路堑高边坡稳定性影响分析［J］.岩石力学与工程学报,2010,29(S1):2982-2987. GAO Wenxue,LIU Hongyu,LIU Hongyang,et al.Road high cutting slope stability analysis under influence of blasting for excavation［J］.Chinese Journal of Rock Mechanics and Engineering,2010,29(S1):2982-2987.
［3］高朋飞,金鹏,杨翎,等.电子雷管在光面爆破中的应用［J］.金属矿山,2018,47(12):56-60. GAO Pengfei,JIN Peng,YANG Ling,et al.Application of electronic detonator to the smooth blasting［J］.Metal Mine,2018,47(12):56-60.
［4］蒲传金.偏心不耦合装药爆破试验研究［J］.化工矿物与加工，2007,37(4):30-43. PU Chuanjin.Test and research on eccentric decouple charge blasting［J］.Chemical Minerals and Processing,2007,37(4):30-43.
［5］管少华,蒲传金,肖定军,等.偏心不耦合装药爆破裂纹扩展实验研究［J］.爆破,2015,32(1):16-21. GUAN Shaohua,PU Chuanjin,XIAO Dingjun,et al.Experimental study on crack propagation under eccentric decouple charge structure［J］.Blasting,2015,32(1):16-21.
［6］岳中文,邱鹏,杨仁树,等.切槽炮孔偏心装药爆源近区裂纹动态力学特征实验研究［J］.岩石力学与工程学报,2017,36(S2):2792-2798. YUE Zhongwen,QIU Peng,YANG Renshu,et al.Experimental study on crack dynamic mechanical characteristic near blasting source of grooved borehole with eccentric decouple charge［J］.Chinese Journal of Rock Mechanics and Engineering,2017,36(S2):2792-2798.
［7］程兵,汪海波,王梦想,等.炮孔偏心不耦合装药爆破效应数值模拟［J］.中国安全生产科学技术,2018,14(7):40-47. CHENG Bing,WANG Haibo,WANG Mengxiang,et al.Numerical simulation on blasting effect of blast hole with eccentric decouple charge［J］.Journal of Safety Science and Technology,2018,14(7):40-47.
［8］宗琦,程兵,汪海波.偏心不耦合装药孔壁压力与损伤效应数值模拟［J］.爆破,2019,36(3):76-83. ZONG Qi,CHENG Bing,WANG Haibo.Numerical simulation of pressure on borehole wall and damage effect with eccentric decouple charge［J］.Blasting,2019,36(3):76-83.
［9］夏祥，李海波，李俊如，等.岩体爆生裂纹的数值模拟［J］.岩土力学，2006，27(11)：1987-1991. XIA Xiang,LI Haibo,LI Junru,et al.Numerical simulation of blast-induced cracks in rock［J］.Rock and Soil Mechanics,2006,27(11):1987-1991.
［10］闫国斌，于亚伦.空气与水介质不耦合装药爆破数值模拟［J］.工程爆破，2009，15(4)：13-19. YAN Guobin,YU Yalun.Numerical simulation of air and water medium decoupling charge balsting［J］.Engineering Blasting,2009,15(4):13-19.
［11］张凤鹏,彭建宇,范光华,等.不同静应力和节理条件下岩体爆破破岩机制研究［J］.岩土力学,2016,37(7):1839-1846. ZHANG Fengpeng,PENG Jianyu,FAN Guanghua,et al.Mechanisms of blasting-induced rock fractures under different static stress and joint properties conditions ［J］.Rock and Soil Mechanics,2016,37(7):1839-1846.
［12］李洪伟,雷战,刘伟,等.起爆方式对岩石柱状装药爆破作用的影响［J］.工程爆破,2019,25(5):28-34. LI Hongwei,LEI Zhan,LIU Wei,et al.Influence of detonation mode on blasting effect of rock columnar charge［J］.Engineering Blasting,2019,25(5):28-34.
［13］胡建华,杨春,周科平,等.单楔形掏槽爆破腔体时空演化及应用［J］.中南大学学报(自然科学版),2017,48(12):3309-3315. HU Jianhua,YANG Chun,ZHOU Keping,et al.Temporal-spatial evolution and application of blasting cavity of single wedge cutting［J］.Journal of Central South University (Science and Technology),2017,48(12):3309-3315.
［14］胡刚,费鸿禄,国志雨.大空孔复式筒形直眼掏槽力学机制与数值模拟分析［J］.中国安全生产科学技术,2018,14(9):129-135. HU Gang,FEI Honglu,GUO Zhiyu.Mechanical mechanism and numerical simulation analysis of compound barrel parallel cut with big cavity［J］.Journal of Safety Science and Technology,2018,14(9):129-135.
［15］方秦，孔祥振，吴昊，等.岩石Holmquist-Johnson-Cook模型参数的确定方法［J］.工程力学，2014，31(3)：197-204. FANG Qin,KONG Xiangzhen,WU Hao,et al.Determination of Holmquist-Johnson-Cook consitiutive model parameters of rock［J］.Engineering Mechanics,2014,31(3):197-204.

相似文献/References:

[1]李亮,孟浩,全超,等.上游式筑坝法尾矿坝的安全系数随堆筑坝高变化分析[J].中国安全生产科学技术,2011,7(7):31.
　Li Liang,Meng Hao,Quan Chao,et al.Study on the variation of factor of safety with the dam height for the tailing dam from upstream embankment method[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2011,7(5):31.
[2]高丙丽.某水电站工程右岸引水发电系统厂房后边坡 稳定性三维有限元分析[J].中国安全生产科学技术,2012,8(5):35.
　GAO Bing li.Three-dimensional finite element analysis on stability of back side slope of water diversion and power generation system powerhouse in right bank of a hydropower engineering[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2012,8(5):35.
[3]贠永峰,王飞.浅析某软岩路堑边坡治理[J].中国安全生产科学技术,2012,8(6):173.
　YUN Yong feng,WANG Fei.Analysis on the slope management of a soft rock cutting[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2012,8(5):173.
[4]王加闯,黄明健,过江.基于CRITIC-有限区间云模型的边坡稳定性评价[J].中国安全生产科学技术,2019,15(6):113.[doi:10.11731/j.issn.1673-193x.2019.06.018]
　WANG Jiachuang,HUANG Mingjian,GUO Jiang.Evaluation of slope stability based on CRITICfinite interval cloud model[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2019,15(5):113.[doi:10.11731/j.issn.1673-193x.2019.06.018]
[5]芦涌峰,侯克鹏,孙华芬,等.不同种类片岩耐崩解特性试验研究*[J].中国安全生产科学技术,2022,18(8):114.[doi:10.11731/j.issn.1673-193x.2022.08.017]
　LU Yongfeng,HOU Kepeng,SUN Huafen,et al.Experimental study on disintegration resistance characteristics of different kinds of schist[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2022,18(5):114.[doi:10.11731/j.issn.1673-193x.2022.08.017]

备注/Memo

备注/Memo:
收稿日期： 2020-01-19
* 基金项目： 江苏省高校优秀科技创新团队项目（2017-51）；盐城工业职业技术学院自然科学课题（ygy1808）
作者简介：丁金画，硕士，助教，主要研究方向为岩土工程。
更新日期/Last Update: 2020-06-10