|本期目录/Table of Contents|

[1]马小敏.超长工作面CO2相变致裂分区增透高效抽采技术试验研究[J].中国安全生产科学技术,2019,15(7):57-61.[doi:10.11731/j.issn.1673-193x.2019.07.009]
 MA Xiaomin.Experimental study on partitioned permeability enhancement highefficiency extraction technology of CO2 phase change fracturing in ultralong working face[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2019,15(7):57-61.[doi:10.11731/j.issn.1673-193x.2019.07.009]
点击复制

超长工作面CO2相变致裂分区增透高效抽采技术试验研究
分享到:

《中国安全生产科学技术》[ISSN:1673-193X/CN:11-5335/TB]

卷:
15
期数:
2019年7期
页码:
57-61
栏目:
职业安全卫生管理与技术
出版日期:
2019-07-31

文章信息/Info

Title:
Experimental study on partitioned permeability enhancement highefficiency extraction technology of CO2 phase change fracturing in ultralong working face
文章编号:
1673-193X(2019)-07-0057-05
作者:
马小敏12
(1.煤科集团沈阳研究院有限公司,辽宁 沈阳 110016;
2.煤矿安全技术国家重点实验室,辽宁 抚顺 113122)
Author(s):
MA Xiaomin12
(1.CCTEG Shenyang Research Institute, Shenyang Liaoning 110016, China;
2.State Key Laboratory of Coal Mine Safety Technology, Fushun Liaoning 113122, China)
关键词:
瓦斯治理分区抽采CO2相变致裂采掘接替紧张抽采达标煤层增透
Keywords:
gas control partitioned extraction CO2 phase change fracturing tension of mining replacement reaching standard of extraction coal seam permeability enhancement
分类号:
X936;TD712
DOI:
10.11731/j.issn.1673-193x.2019.07.009
文献标志码:
A
摘要:
针对超长工作面抽采时间不均衡导致抽采达标时间长的问题,提出了工作面分区增透高效抽采技术,运用分组试验和理论分析的方法,研究了不同布孔工艺参数条件下CO2相变致裂对低透煤层瓦斯抽采的增透作用规律,并在试验工作面进行了工业应用。研究结果表明:CO2相变致裂技术对低透煤层增透促抽效果良好,与未致裂抽采相比,采用间距20,10,5 m致裂孔致裂条件下进行抽采时煤层透气性系数分别提高1.8,2.6,5.8倍,平均抽采体积分数分别提高1.9,3.5,4.2倍,平均抽采纯量分别提高2.4,4.2,6.2倍。试验工作面应用分区增透高效抽采技术后,整个工作面形成后仅需抽采87 d即可达标进行回采,显著缩短了抽采周期,对高瓦斯低透煤层缓解采掘接替紧张及提高瓦斯抽采效率具有重要借鉴意义。
Abstract:
Aiming at the problem that the uneven extraction time of ultralong working face leads to a long time to reach the standard of extraction, a technology of partitioned permeability enhancement highefficiency extraction for the working face was put forward. By means of grouping experiment and theoretical analysis, the laws of permeability enhancement for the gas extraction in low permeability coal seam by CO2 phase change fracturing under different hole distribution parameters were studied, and the industrial application was carried out in the experimental working face. The results showed that CO2 phase change fracturing technology had good effect on permeability enhancement and extraction promotion in the low permeability coal seam. Compared with the nonfractured extraction, when the spacing of fracturing holes was 20, 10 and 5 m for the fractured extraction, the permeability coefficient of coal seam increased by 1.8, 2.6 and 5.8 times, the average extraction volume fraction increased by 1.9, 3.5 and 4.2 times, and the average extraction pure quantity increased by 2.4, 4.2 and 6.2 times respectively. After the application of partitioned permeability enhancement highefficiency extraction technology in the experimental working face, the whole working face could reach the standard for mining with only 87 days of extraction after it was formed, which significantly shortened the extraction period. It has important reference significance for alleviating the tension of mining replacement and improving the efficiency of gas extraction in the high gas and low permeability coal seams.

参考文献/References:

[1]傅雪海,秦勇,韦重韬.煤层气地质学[M].徐州:中国矿业大学出版社,2007.
[2]俞启香,程远平.矿井瓦斯防治[M].徐州:中国矿业大学出版社,2012.
[3]申宝宏,刘见中,雷毅.我国煤矿区煤层气开发利用技术现状及展望[J].煤炭科学技术,2015,43(2):1-4.SHEN Baohong,LIU Jianzhong,LEI Yi.Present status and prospects of coalbed methane development and utilization technology of coal mine area in China[J].Coal Science and Technology,2015,43(2):1-4.
[4]龚敏,黄毅华,王德胜,等.松软煤层深孔预裂爆破力学特性的数值分析[J].岩石力学与工程学报,2008,27(8):1674-1681.GONG Min,HUANG Yihua,WANG Desheng,et al.Numerical simulation on mechanical characteristics of deep-hole presplitting blasting in soft coal bed[J].Chinese Journal of Rock Mechanics and Engineering,2008,27(8):1674-1681.
[5]蔡峰.高瓦斯低透气性煤层深孔预裂爆破强化增透效应研究[D].淮南:安徽理工大学,2007.
[6]王兆丰,王林,陈向军.深孔预裂爆破在高瓦斯特厚煤层回采中的应用[J].煤炭科学技术,2008,36(8):31-33.WANG Zhaofeng,WANG Lin,CHEN Xiangjun.Application of deep borehole pre-cracking blasting to coalmining in high gassy and ultra thick seam[J].Coal Science and Technology,2008,36(8):31-33.
[7]袁亮,林柏泉,杨威.我国煤矿水力化技术瓦斯治理研究进展及发展方向[J].煤炭科学技术,2015,43(1):45-49.YUAN Liang,LIN Baiquan,YANG Wei.Research progress and development direction of gas control with mine hydraulic technology in China coal[J].Coal Science and Technology,2015,43(1):45-49.
[8]刘明举,任培良,刘彦伟,等.水力冲孔防突措施的破煤理论分析[J].河南理工大学学报(自然科学版),2009,28(2):142-245.LIU Mingju,REN Peiliang,LIU Yanwei,et al.Breaking coal theoretical analysis of outburst prevention by hydraulic flushing[J].Journal of Henan Polytechnic University(Nature Science),2009,28(2):142-245.
[9]孙炳兴,王兆丰,伍厚荣.水力压裂增透技术在瓦斯抽采中的应用[J].煤炭科学技术,2010,38(11):78-80.SUN Bingxing,WANG Zhaofeng,WU Hourong.Hydraulic pressurized cracking and permeability improvement technology applied to gas drainage[J].Coal Science and Technology,2010,38(11):78-80.
[10]邹全乐,林柏泉,刘厅,等.割缝预抽后煤瓦斯吸附特性的变化特征[J].岩石力学与工程学报,2014,33(10):2117-2124.ZOU Quanle,LIN Baiquan,LIU Ting,et al.Variation of gas adsorption of coal after hydraulic slotting and pre-draining[J].Chinese Journal of Rock Mechanics and Engineering,2014,33(10):2117-2124.
[11]王耀锋,李艳增.预置导向槽定向水力压穿增透技术及应用[J].煤炭学报,2012,37(8):1326-1331.WANG Yaofeng,LI Yanzeng.Technology and application of directional hydraulic penetration permeability improvement by guided groove[J]. Journal of China Coal Society,2012,37(8):1326-1331.
[12]王兆丰,孙小明,陆庭侃,等.液态CO2相变致裂强化瓦斯预抽试验研究[J],河南理工大学学报(自然科学版),2015,34(1):1-5.WANG Zhaofeng,SUN Xiaoming,LU Tingkan,et al.Experiment research on strengthening gas drainage effect with fracturing technique by liquid CO2 phase transition[J].Journal of Henan Polytechnic University(Nature Science), 2015,34(1):1-5.
[13]孙文忠.低渗煤层CO2预裂增透高效瓦斯抽采原理及应用[J].煤炭科学技术,2017,45(1):100-105.SUN Wenzhong.High efficient gas drainage principle and application of low permeable seam with CO2 pre-fracturing and permeability improvement[J].Coal Science and Technology,2017,45(1):100-105.
[14]任志成,杜刚,年军.高瓦斯煤层液态CO2致裂消突巷道快速掘进技术[J].煤矿安全,2017,48(5):77-80.REN Zhicheng,DU Gang,NIAN Jun.Research on gateway quick driving by high pressure liquid CO2 fracturing and outburst removing technology in high gas seam[J].Safety in Coal Mines,2017,48(5):77-80.
[15]张东明,白鑫,尹光志,等.低渗煤层液态CO2相变定向射孔致裂增透技术及应用[J].煤炭学报,2018,43(7):1938-1950.ZHANG Dongming,BAI Xin,YIN Guangzhi,et al.Research and application on technology of increased permeability by liquid CO2 phasechange directional jet fracturing in low-permeability coal seam[J].Journal of China Coal Society,2018,43(7):1938-1950.
[16]霍中刚.二氧化碳致裂器深孔预裂爆破煤层增透新技术[J].煤炭科学技术,2015,43(2):80-83.HUO Zhonggang.New technology of carbon dioxide fracturer applied to deep borehole pre-cracking blasting for seam permeability improvement[J].Coal Science and Technology,2015, 43(2):80-83.[17]洪紫杰,王成,熊祖强.高瓦斯低透气性煤层CO2相变致裂增透技术研究[J].中国安全生产科学技术,2017,13(1):39-45.HONG Zijie,WANG Cheng,XIONG Zuqiang.Research on CO2 phase-transition fracturing technology for permeability improvement in high gas and low permeability coal seam[J].Journal of Safety Science and Technology,2017,13(1):39-45.
[18]王兆丰,李豪君,陈喜恩,等.液态CO2相变致裂煤层增透技术布孔方式研究[J].中国安全生产科学技术,2015,11(9):11-16.WANG Zhaofeng,LI Haojun,CHEN Xien, et al. Study on hole layout of liquid CO2 phase-transforming fracture technology for permeability improvement of coal seam[J].Journal of Safety Science and Technology,2015,11(9):11-16.
[19]罗朝义,江泽标,郑昌盛,等.CO2相变致裂技术在顺煤层钻孔增透中的应用[J].煤炭科学技术,2017,45(11):138-143.LUO Chaoyi,JIANG Zebiao,ZHENG Changsheng,et al.Application on permeability improvement technology with CO2 phase change to borehole drilling along coal seam[J].Coal Science and Technology,2017,45(11):138-143.
[20]雷云,刘建军,张哨楠.CO2相变致裂本煤层增透技术研究[J].工程地质学报,2017,25(1):215-221.LEI Yun,LIU Jianjun,ZHANG Shaonan.Permeability improvement technology by cracking coal seam with CO2 phase transition[J].Journal of Engineering Geology,2017,25(1):215-221.
[21]梁卫国,张倍宁,韩俊杰,等.超临界CO2驱替煤层CH4装置及试验研究[J].煤炭学报,2014,39(8):1511-1520.LIANG Weiguo,ZHANG Beining,HAN Junjie,et al.Experimental study on coal bed methane displacement and recovery by super critical carbon dioxide injection[J].Journal of China Coal Society,2014,39(8):1511-1520.

相似文献/References:

[1]王彦波,谢贤平,李锦峰,等.基于FAHP的煤矿瓦斯治理综合评价研究[J].中国安全生产科学技术,2012,8(11):101.
 WANG Yan bo,XIE Xian ping,LI Jin feng,et al.Study on comprehensive evaluation of coal mine gas control based on FAHP[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2012,8(7):101.
[2]周中立,白彦龙,刘向伟.瓦斯异常区域高位裂隙抽放技术探析[J].中国安全生产科学技术,2013,9(9):111.[doi:10.11731/j.issn.1673-193x.2013.09.021]
 ZHOU Zhong li,BAI Yan long,LIU Xiang wei.Analysis on high fracture drainage technology in gas uneven area[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2013,9(7):111.[doi:10.11731/j.issn.1673-193x.2013.09.021]
[3]徐雪战,孟祥瑞,赵光明,等.基于三维可视化的卸压区瓦斯穿层抽采仿真研究[J].中国安全生产科学技术,2014,10(9):77.[doi:10.11731/j.issn.1673-193x.2014.09.013]
 XU Xue-zhan,MENG Xiang-rui,ZHAO Guang-ming,et al.Virtual simulation of gas drainage drilling through layers in stress-relaxation zone based on three-dimensional visualization[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2014,10(7):77.[doi:10.11731/j.issn.1673-193x.2014.09.013]
[4]李杰,孙珍平.地面L型钻孔在大采高综放工作面瓦斯治理工作中的探索[J].中国安全生产科学技术,2017,13(3):64.[doi:10.11731/j.issn.1673-193x.2017.03.010]
 LI Jie,SUN Zhenping.Exploration of gas control by ground L-type borehole on fully mechanized caving face with large mining height[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2017,13(7):64.[doi:10.11731/j.issn.1673-193x.2017.03.010]
[5]赵洪宝,王宏冰,张欢,等.井下采空区构筑物漏风实测装置研发及应用[J].中国安全生产科学技术,2018,14(8):123.[doi:10.11731/j.issn.1673-193x.2018.08.020]
 ZHAO Hongbao,WANG Hongbing,ZHANG Huan,et al.Development and application of air leakage measurement device for structure in underground goaf[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2018,14(7):123.[doi:10.11731/j.issn.1673-193x.2018.08.020]

备注/Memo

备注/Memo:
收稿日期: 2019-04-09;数字出版日期: 2019-07-30
* 基金项目: 国家科技重大专项项目(2016ZX05067-004-003);中国煤炭科工集团有限公司科技创新基金项目(2018-2-QN015)
作者简介: 马小敏,硕士,助理研究员,主要研究方向为煤矿瓦斯灾害预警及防治技术。
更新日期/Last Update: 2019-08-07