|本期目录/Table of Contents|

[1]凡永鹏,穆晓刚,师超.“U+I”型采煤工作面瓦斯抽采与浮煤自燃耦合研究[J].中国安全生产科学技术,2017,13(5):96-102.[doi:10.11731/j.issn.1673-193x.2017.05.016]
　FAN Yongpeng,MU Xiaogang,SHI Chao.Study on coupling between gas drainage and spontaneous combustion of float coal on "U+I" type coal mining working face[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2017,13(5):96-102.[doi:10.11731/j.issn.1673-193x.2017.05.016]
点击复制

“U+I”型采煤工作面瓦斯抽采与浮煤自燃耦合研究
分享到：

《中国安全生产科学技术》[ISSN:1673-193X/CN:11-5335/TB]

卷:
13
期数:
2017年5期
页码:
96-102
栏目:
现代职业安全卫生管理与技术
出版日期:
2017-05-31

文章信息/Info

Title:
Study on coupling between gas drainage and spontaneous combustion of float coal on "U+I" type coal mining working face
文章编号:
1673-193X(2017)-05-0096-07
作者:
凡永鹏1; 2; 穆晓刚2; 师超1
1. 辽宁工程技术大学 矿业学院，辽宁 阜新 123000；2. 辽宁工程技术大学 安全工程技术研究院，辽宁 阜新 123000
Author(s):
FAN Yongpeng1; 2;  MU Xiaogang2;  SHI Chao1
1. College of Mining Engineering, Liaoning Technical University, Fuxin Liaoning 123000, China; 2. Safety Engineering Technology Research Institute, Liaoning Technical University, Fuxin Liaoning 123000, China
关键词:
采空区; 顶板巷; 漏风; 瓦斯抽采; 煤自燃
Keywords:
goaf;  roof roadway;  air leakage;  gas drainage;  spontaneous combustion of coal
分类号:
X936
DOI:
10.11731/j.issn.1673-193x.2017.05.016
文献标志码:
A
摘要:
为了研究“U+I”型工作面进风量和顶板巷抽采负压对工作面瓦斯浓度与采空区氧化带宽度的影响，协调瓦斯抽采和浮煤自燃之间的关系。以2306综放面为工程背景，基于“U”型冒落岩层孔隙率分布公式和流体通用控制方程建立采空区数值模拟解算模型。采用CFD软件对不同进风量、不同抽采负压下的工作面瓦斯浓度和采空区氧化带宽度进行模拟，结果表明：随着工作面风量的增加，工作面和顶板巷瓦斯浓度减小，但工作面处浓度减幅逐渐变小而顶板巷浓度减幅几乎不变；提高顶板巷抽采负压，对减少工作面瓦斯浓度效果明显，顶板巷自身瓦斯浓度先增加再减小，采空区进风侧氧化带宽度变窄，回风侧和采空区中部氧化带宽度增加，总体上增加了采空区浮煤自燃的危险性但影响程度有限。
Abstract:
In order to study the influence of supply air rate and drainage negative pressure in roof roadway at "U+I" type working face on the gas concentration of working face and the width of oxidation zone in goaf, and coordinate the relationship between gas drainage and spontaneous combustion of float coal, a numerical simulation model of the goaf was established based on the void fraction distribution formula of "U" type caving rock layer and the general governing equations of fluid by taking the 2306 fully mechanized caving face as the engineering background. The gas concentrations of working face and the widths of oxidation zone in goaf under different supply air rates and drainage negative pressures were simulated by using CFD software. The results showed that with the increase of supply air rate in the working face, the gas concentration in the working face and roof roadway decreased, but the reduction amplitude of the gas concentration in the working face became smaller gradually, while that in the roof roadway was almost unchanged. Increasing the drainage negative pressures in the roof roadway presented an obvious effect on decreasing the gas concentration in the working face, and the gas concentration in the roof roadway increased first and then decreased. The width of oxidation zone in air intake side of goaf became narrower, and the width of oxidation zone in air return side and the middle of goaf increased. The risk of spontaneous combustion of float coal in goaf increased as a whole, but the degree of influence was limited.

参考文献/References:

［1］刘大伟,王益山,虞海法,等.煤层多分支水平井安全钻井技术［J］.煤炭学报,2011,36(12):2109-2114. LIU Dawei, WANG Yishan, YU Haifa, et al. Safety drilling technology of multi-lateral horizontal wells in coal bed［J］. Journal of China Coal Society,2011,36(12):2109-2114.
［2］王德明.矿井火灾学［M］．徐州: 中国矿业大学出版社，2008．
［3］褚廷湘,余明高,姜德义,等.“U+I”型采煤工作面采空区瓦斯抽采量理论研究［J］. 中国矿业大学学报,2015,44(6):1008-1016. CHU Tingxiang, YU Minggao, JIANG Deyi, et al. Theoretical study on gas drainage in goaf of "U+I" coal face［J］. Journal of China University of Ming &Technology,2015,44(6):1008-1016.
［4］王洪胜.综采放顶煤开采瓦斯运移规律及控制技术应用研究［D］.北京：北京科技大学,2016.
［5］杨胜强,程涛,徐全,等.尾巷风压及风量变化对采空区自然发火影响的理论分析与数值模拟［J］. 煤炭学报,2011,36(2):308-312. YANG Shengqiang, CHENG Tao, XU Quan, et al. Theoretical analysis and numerical simulation of influence of the change of negative pressure and air volume of inner interlocked tail road on coal spontaneous combustion［J］. Journal of China Coal Society,2011,36(2):308-312.
［6］张明.基于工作面顶板巷“一巷两用”的试验及应用［J］.矿业安全与环保,2016,43(6):1-3. ZHANG Ming. Test and application of “one lane for two uses” based on roof road way of working face［J］. Mining Safety & Environmental Protection,2016,43(6):1-3.
［7］张玫润,杨胜强,程健维,等.一面四巷高位瓦斯抽采及浮煤自燃耦合研究［J］.中国矿业大学学报,2013,42(4):513-518. ZHANG Meirun, YANG Shengqiang, CHENG Jianwei, et al. Study on the coupling of high gas drainage and spontaneous combustion of coal seam in one side of four roadways［J］. Journal of China University of Ming &Technology, 2013,42(4):513-518.
［8］翟云芳.渗流力学［M］.北京:石油工业出版社,1996:25-30.
［9］王福军.计算流体动力学分析:CFD软件原理与应用［M］.北京:清华大学出版社,2004:10-14.
［10］钱鸣高,石平五,许家林.矿山压力与岩层控制［M］.徐州:中国矿业大学出版社,2012:187-188.
［11］李俊平,连民杰. 矿山岩石力学［M］.北京:冶金工业出版社,2011:18-21.
［12］李宗翔,衣刚,武建国,等.基于“O”型冒落及耗氧非均匀采空区自燃分布特征［J］.煤炭学报,2012,37(3):484-489. LI Zongxiang, YI Gang, WU Jianguo, et al. Study on spontaneous combustion distribution of goaf based on the “O”type risked falling and non-uniform oxygen［J］. Journal of China Coal Society, 2012,37(3):484-489.
［13］Yuan L, Smith A C. Computational fluid dynamics modeling of spontaneous heating in long wall gob areas［J］.Transactions,2007:37-44.
［14］李宗翔.高瓦斯易自燃采空区瓦斯与自燃耦合研究［D］.阜新：辽宁工程技术大学,2007.

相似文献/References:

[1]吕文陵,杨胜强,徐全,等.高瓦斯矿井孤岛综放采空区遗煤自燃综合防治技术[J].中国安全生产科学技术,2010,6(5):60.
　LV Wen-ling,YANG Sheng-qiang,XU Quan,et al.Prevention and extinguishment technology of spontaneous combustion for isolated island fully mechanized caving goaf in high-gas mine[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2010,6(5):60.
[2]胡家国,马海涛.铁矿采空区处理方案研究[J].中国安全生产科学技术,2010,6(5):67.
　HU Jia-guo,MA Hai-tao.Study of on treating method of goaf in iron-mine[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2010,6(5):67.
[3]何磊,杨胜强,孙祺,等.Y型通风下采空区瓦斯运移规律及治理研究[J].中国安全生产科学技术,2011,7(2):50.
　HE Lei,YANG Sheng qiang,SUN Qi,et al.Study on gas transportation principle and control in goaf with Yshape ventilation system[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2011,7(5):50.
[4]马海涛,刘勇锋,胡家国.基于C-ALS采空区探测及三维模型可视化研究[J].中国安全生产科学技术,2010,6(3):38.
　MA Hai-tao,LIU Yong-feng,HU Jia-guo.Study on Gob detection and visualization of three-dimensional model based on C-ALS[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2010,6(5):38.
[5]刘勇锋,马海涛,付士根.综合物探技术在老空区水害防治中的应用[J].中国安全生产科学技术,2010,6(6):103.
　LIU Yong-feng,MA Hai-tao,FU Shi-gen.Application of comprehensive geophysical exploration technology in prevention and control of goaf water disaster[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2010,6(5):103.
[6]齐福荣,李忠,武强.信息融合技术在采空区安全评价中的应用研究[J].中国安全生产科学技术,2010,6(1):13.
　QI Fu-rong,LI Zhong,WU Qiang.Information fusion and it’s application in evaluation of coal-goaf safety[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2010,6(5):13.
[7]马海涛 ,谢芳  .大规模采空区渐进式矿柱坍塌的简化模拟[J].中国安全生产科学技术,2013,9(8):17.[doi:10.11731/j.issn.1673-193x.2013.08.003]
　MA Hai tao,XIE Fang.Simplified simulation on cascading pillar failure in largescale goaf[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2013,9(5):17.[doi:10.11731/j.issn.1673-193x.2013.08.003]
[8]陈娇,罗周全,侯造水.基于改进突变级数法的金属矿采空区稳定性评价[J].中国安全生产科学技术,2013,9(11):17.[doi:10.11731/j.issn.1673-193x.2013.11.003]
　CHEN Jiao,LUO Zhou quan,HOU Zao shui.Stability evaluation of metal mine goaf based on improved catastrophe progression method[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2013,9(5):17.[doi:10.11731/j.issn.1673-193x.2013.11.003]
[9]王海燕,冯超,耿兰,等.基于能位测定和示踪检测法的地下煤火漏风状态研究[J].中国安全生产科学技术,2014,10(1):118.[doi:10.11731/j.issn.1673-193x.2014.01.020]
　WANG Hai yan,FENG Chao,GENG Lan,et al.Study on air leakage in underground coal fire based on energy level and tracer test[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2014,10(5):118.[doi:10.11731/j.issn.1673-193x.2014.01.020]
[10]丘 帆,马海涛,欧阳明,等.基于Voronoi图和时间效应的矿柱失稳预测[J].中国安全生产科学技术,2014,10(2):38.[doi:10.11731/j.issn.1673-193x.2014.02.007]
　QIU Fan,MA Hai tao,OUYANG Ming,et al.Prediction of pillar instability based on Voronoi chart and time effect[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2014,10(5):38.[doi:10.11731/j.issn.1673-193x.2014.02.007]

备注/Memo

备注/Memo:
国家自然基金面上项目（51574143）；国家自然科学青年基金项目（51604144）
更新日期/Last Update: 2017-06-09