|本期目录/Table of Contents|

[1]周晓晖,苏义脑,程远方,等.极地冻土低温力学特性及井眼坍塌风险分析*[J].中国安全生产科学技术,2021,17(4):5-11.[doi:10.11731/j.issn.1673-193x.2021.04.001]
　ZHOU Xiaohui,SU Yinao,CHENG Yuanfang,et al.Analysis on low-temperature mechanical properties of polar frozen soil and borehole collapse risk[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2021,17(4):5-11.[doi:10.11731/j.issn.1673-193x.2021.04.001]
点击复制

极地冻土低温力学特性及井眼坍塌风险分析*
分享到：

《中国安全生产科学技术》[ISSN:1673-193X/CN:11-5335/TB]

卷:
17
期数:
2021年4期
页码:
5-11
栏目:
学术论著
出版日期:
2021-04-30

文章信息/Info

Title:
Analysis on low-temperature mechanical properties of polar frozen soil and borehole collapse risk
文章编号:
1673-193X(2021)-04-0005-07
作者:
周晓晖; 苏义脑; 程远方; 李庆超
(1.中国石油大学（华东） 石油工程学院，山东 青岛 266580；
2.河南理工大学 能源科学与工程学院，河南 焦作 454000)
Author(s):
ZHOU Xiaohui;  SU Yinao;  CHENG Yuanfang;  LI Qingchao
(1.School of Petroleum Engineering,China University of Petroleum (East China),Qingdao Shandong 266580,China;
2.School of Energy Science and Engineering,Henan Polytechnic University,Jiaozuo Henan 454000,China)
关键词:
多年冻土层; 极限强度; 力学特性; 钻井作业; 井眼稳定性
Keywords:
permafrost layer;  ultimate strength;  mechanical property;  drilling operation;  borehole instability
分类号:
X937
DOI:
10.11731/j.issn.1673-193x.2021.04.001
文献标志码:
A
摘要:
为解决极地冻土区油气资源储量极大但其力学特性和钻井井壁失稳机理尚不清晰的问题，对冻土岩样开展低温三轴力学特性实验，并基于此开展钻井井壁坍塌失稳相关数值模拟分析。结果表明：冻土的极限强度会随温度的降低和围压的增大而逐渐提高；冻土弹性模量尽管会随温度的降低而增加，但受围压影响较小，而泊松比基本不受温度及围压的影响；冻土内聚力会随实验温度的降低得到较大幅度提升，但不同实验温度范围内温度对冻土内聚力的影响程度存在差异，实验温度高于-12.5 ℃时温度对冻土内聚力的影响较强；极地冻土储层钻井过程近井地带冰的分解会随钻井作业的进行而逐渐变慢，冰的最终分解前缘位置为0.079 6 m，井眼扩大率达到63.51%。研究结果可为极地冻土层油气资源钻井作业设计提供参考与指导。
Abstract:
In order to solve the problems of extremely large reserves of oil and gas resources in the polar frozen soil area but its mechanical properties and the instability mechanism of drilling borehole wall are not clear,the low-temperature triaxial mechanical properties experiments were carried out on the frozen soil rock samples,and on this basis,the relevant numerical simulation analysis on the collapse and instability of drilling borehole wall was carried out.The results showed that the ultimate strength of frozen soil would gradually increase with the decreasing temperature and the increasing confining pressure.Although the elastic modulus of frozen soil would increase with the decrease of temperature,it was less affected by the confining pressure.However,the Poisson’s ratio was basically unaffected by the temperature and confining pressure.Moreover,the cohesion of frozen soil would greatly increase with the decrease of temperature,but the influence degree of temperature on the cohesion of frozen soil was different in different experimental temperature ranges,and the influence of temperature on the cohesion of frozen soil was stronger in the range of experimental temperature higher than -12.5 ℃.The ice decomposition in the nearwellbore zone would gradually slow down during the drilling process of polar frozen soil reservoir,the final position of ice decomposition front was 0.0796 m,and the borehole expansion rate reached 63.51%.The results can provide reference and guidance for the design of drilling operation for the oil and gas resources in polar frozen soil layer.

参考文献/References:

［1］WANGX R,WANG Z Y,DENG X J,et al.Coupled thermal model of wellbore and permafrost in Arctic regions［J］.Applied Thermal Engineering,2017,123:1291-1299.
［2］王春娟.中国开发利用北极油气资源战略研究［D］.北京:中国地质大学(北京),2018.
［3］王淑玲,姜重昕,金玺.北极的战略意义及油气资源开发［J］.中国矿业,2018,27(1):20-26. WANG Shuling,JIANG Chongxin,JIN Xi.The strategic significance of the Arctic and the development of oil and gas resources［J］.China Mining Magazine,2018,27(1):20-26.
［4］明锋,李冬庆,张宇.一维饱和冻土融化固结分析［J］.冰川冻土,2016,38(4):1067-1073. MING Feng,LI Dongqing,ZHANG Yu.One dimensional thaw settlement of saturated frozen soil［J］.Journal of Glaciology and Geocryology,2016,38(4):1067-1073.
［5］袁伟,姚晓亮,王文丽.基于离散元的冻结砂土三轴力学特性研究［J］.冰川冻土,2019,41(6):1388-1396. YUAN Wei,YAO Xiaoliang,WANG Wenli.Study on triaxial mechanical behaviors of frozen sand based on discrete element method［J］.Journal of Glaciology and Geocryology,2019,41(6):1388-1396.
［6］ZHANG Y.Thermal-Hydrao-Mechanical model for freezing and thawing of soils［D］.Michigan:University of Michigan,2014.
［7］AKHTAR S.Numerical analysis of pipeline uplift resistance in a frozen clay soil subjected to temperature changes［D］.Montreal：Concordia University,2018.
［8］李庆超,程远方,李强,等.水合物储层安全钻井液密度下限确定方法［J］.大庆石油地质与开发,2018,37(5):168-174. LI Qingchao,CHENG Yuanfang,LI Qiang,et al.Determining method of the safe lower limit of the drilling fluid density in hydrate-bearing formations［J］.Petroleum Geology & Oilfield Development in Daqing,2018,37(5):168-174.
［9］李庆超,程远方,鲁钟强,等.钻井液特性对近井地带水合物分解的影响［J］.大庆石油地质与开发,2019,38(3):59-64. LI Qingchao,CHENG Yuanfang,LU Zhongqiang,et al.Influences of the drilling fluid properties on the hydrate dissociation nearby the wellbore［J］.Petroleum Geology & Oilfield Development in Daqing,2019,38(3):59-64.
［10］LI Q C,CHENG Y F,LI Q,et al.Investigation method of borehole collapse with the multi-field coupled model during drilling in clayey silt hydrate reservoirs［J］.Frattura ed Integrità Strutturale,2018,12(45):86-99.
［11］LI Y,CHENGY F,YAN C L,et al.Influence of drilling fluid temperature on borehole shrinkage during drilling operation in cold regions［J］.Journal of Petroleum Science and Engineering,2020,190:107050.
［12］路贵林.多年冻土区高温冻土力学特性试验研究［D］.徐州:中国矿业大学,2015.
［13］薛楠.吉林地区季冻土力学特性试验研究［D］.长春:东北电力大学,2017.
［14］武宁.深季节冻土区粉砂土力学性质试验研究［D］.石家庄:石家庄铁道大学,2014.
［15］LI Q C,LIU L L,YU B H,er al.Borehole enlargement rate as a measure of borehole instability in hydrate reservoir and its relationship with drilling mud density［J］.Journal of Petroleum Exploration and Production,2021,11(3):1185-1198.
［16］WANG K.Simulation and analysis of wellbore stability in permafrost formation with FLAC［D］.Fairbanks:University of Alaska,2015.
［17］卢方超,张学博.倾斜特厚煤层采空区孔隙率分布规律研究［J］.中国安全生产科学技术,2020,16(8):119-124. LU Fangchao,ZHANG Xuebo.Research on porosity distribution laws of goaf in inclined extra-thick coal seam［J］.Journal of Safety Science and Technology,2020,16(8):119-124.
［18］SOHAIL A.Numerical analysis of pipeline uplift resistance in a frozen clay soil subjected to temperature changes［D］.Montreal:Concordia University,2018.

相似文献/References:

备注/Memo

备注/Memo:
收稿日期： 2020-09-09
* 基金项目： 国家重点研发计划项目(2016YFC0303300)
作者简介： 周晓晖，博士研究生，主要研究方向为极地冻土基本力学特性及其井壁稳定。
通信作者： 苏义脑，中国工程院院士，博士，教授，主要研究方向为油气井随钻测量与导向控制工程基础理论、产品开发与技术应用。
更新日期/Last Update: 2021-05-09