|本期目录/Table of Contents|

[1]高少华,邹兵,严龙,等.含硫天然气净化厂硫化氢泄漏分析及对策[J].中国安全生产科学技术,2012,8(2):174.
　GAO Shao hua,ZOU Bing,YAN Long,et al.Study of hydrogen sulfide leakage and dispersion in sour gas purification plants and countermeasures[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2012,8(2):174.
点击复制

含硫天然气净化厂硫化氢泄漏分析及对策
分享到：

《中国安全生产科学技术》[ISSN:1673-193X/CN:11-5335/TB]

卷:
8
期数:
2012年2期
页码:
174
栏目:
出版日期:
2012-02-29

文章信息/Info

Title:
Study of hydrogen sulfide leakage and dispersion in sour gas purification plants and countermeasures
作者:
高少华; 邹兵; 严龙; 张贺; 王振
中国石油化工股份有限公司青岛安全工程研究院，青岛 266071
Author(s):
GAO Shaohua;  ZOU Bing;  YAN Long;  ZHANG He;  WANG Zhen
SINOPEC Safety Engineering Institute, Shandong, Qingdao 266071, China
关键词:
硫化氢; 泄漏; 扩散; 天然气净化; 脱硫; 硫磺回收; 立即危及生命或健康
Keywords:
hydrogen sulfide;  leak;  dispersion;  natural gas purification;  desulphurization;  sulfur recovery;  IDLH
分类号:
X937；TE64
DOI:
-
文献标志码:
A
摘要:
以川东北某含硫天然气净化厂为对象，通过分析该净化厂的处理工艺及可能造成泄漏的各种原因，确定了硫化氢泄漏危险较高的生产单元。通过工艺压力、流量、物料组分的比对，选取了脱硫单元原料气和硫磺回收单元酸性气作为模拟泄漏物料。对该厂所在地的气象条件和厂区的地形地貌进行了调查，净化厂当地近5年风速、云量统计表明低风速和多云为主导天气, 将D15m/s作为模拟硫化氢泄漏扩散的典型气象条件。采用了美国石油学会（API）推荐地面粗糙度长度。运用PHAST软件计算了在典型气象条件下通过3种不同孔径泄漏1 min，5min和30min，形成的立即危及生命或健康(IDLH)范围。在典型气象条件下IDLH的下风向边界距离在41m至1190m范围内，以硫磺回收单元的大孔径泄漏为最远。以小孔泄漏为例模拟并讨论了风速、大气稳定度对硫化氢扩散的影响。为降低H2S泄漏风险提出了在线监测及联锁系统设置的要求，对避免和减少硫化氢中毒伤亡事故具有指导意义。
Abstract:
Processing facilities with higher risk of H2S leakage were determined through analyzing purifying process and various causes that may result in leakage from one of the sour gas plants in Northeastern Sichuan. The feed gas in the desulphurization units and acid gas in the sulfur recovery units , mainly consisting of H2S and CO2 ,were selected for the simulation through comparing the process pressures, flow rates and material compositions. Weather conditions and terrains around the plant were studied. According to the statistics of local meteorological data during the last 5 years, low wind speed and cloudy weather were typical weather conditions, and D15m/s was selected for calculation of hydrogen sulfide dispersion at the plant. Surface roughness length recommended for small refineries by American Petroleum Institute was adopted. The Immediately Dangerous to Life or Health (IDLH )zones resulted from the hazardous gas dispersions were calculated with PHAST based on three different leakage holes with 1min, 5min and 30min. The IDLH downwind distances range from 41m to 1190m with the farthest one resulting from the large hole release of feed gas from the desulphurization units under the typical weather. The effects of wind speeds and atmospheric stabilities on the H2S dispersion were also simulated and discussed with small hole release. Some suggestions were made for setting online leak detection and interlock systems in order to reduce the risk of H2S leakage It has instructive meanings in avoiding or reducing casualties due to hydrogen sulfide poisoning.

参考文献/References:

-

相似文献/References:

[1]丁德武,邹兵,高少华,等.危化品突发泄漏事故应急监测标准化作业研究[J].中国安全生产科学技术,2010,6(4):61.
　DING De-wu,ZOU Bing,GAO Shao-hua,et al.Research on standard operation procedure of emergency inspection in hazardous chemicals leakage accident[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2010,6(2):61.
[2]赵文芳.高硫油炼制企业H2S中毒风险分析[J].中国安全生产科学技术,2010,6(4):135.
　ZHAO Wen-fang.Analysis on the risk of hydrogen sulfide poisoning in high-sulfur oil refining enterprises[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2010,6(2):135.
[3]王文静,孙标,郭开华.液化天然气场站事故定量风险评价方法研究[J].中国安全生产科学技术,2011,7(4):114.
　WANG Wen-jing,SUN Biao,GUO Kai-hua.Quantitative Risk Analysis for LNG Station Accidents[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2011,7(2):114.
[4]李朝阳,马贵阳,徐柳.架空及埋地天然气管道泄漏扩散数值研究[J].中国安全生产科学技术,2011,7(7):66.
　LI Zhao-yang,MA Gui-yang,XU Liu.The numerical study of the diffusion concentration on buried and Overhead[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2011,7(2):66.
[5]王善文.国内外含硫气田应急预案编制对比分析研究[J].中国安全生产科学技术,2011,7(10):46.
　WANG Shan-wen.Comparison study on emergency planning of nature gas well involving hydrogen sulfide[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2011,7(2):46.
[6]郭再富,张明明.毒气泄漏事故应急用个体呼吸防护用品防护效果研究[J].中国安全生产科学技术,2012,8(3):48.
　GUO Zai fu,ZHANG Ming ming.Study on protection performance of individual respiratory[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2012,8(2):48.
[7]谢昱姝,吴宗之,吕良海,等.城市管道天然气在土壤中泄漏扩散实验研究[J].中国安全生产科学技术,2012,8(4):13.
　XIE Yu shu,WU Zong zhi,L Liang hai,et al.Experimental research on diffusion behavior of leaked gas from underground gas pipeline[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2012,8(2):13.
[8]庞〓磊,,吕良海,等.密闭空间燃气泄漏爆炸危险区域迁移规律[J].中国安全生产科学技术,2012,8(8):47.
　PANG Lei,LV Liang hai,et al.Migration laws of hazardous zone for natural gas leakage explosion in enclosed spaces[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2012,8(2):47.
[9]刘瑞凯,吴〓明,王同秀,等.海底埋地热油管道泄漏扩散的数值模拟[J].中国安全生产科学技术,2012,8(8):63.
　LIU Rui kai,WU Ming,WANG Tong xiu,et al.Numerical simulation on leakage and diffusion of submarine buried hot oil pipeline[J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2012,8(2):63.
[10]邹〓兵,朱胜杰,石〓昕.硫化氢捕消剂清除硫化氢效果研究[J].中国安全生产科学技术,2012,8(9):48.
　ZOU Bing,ZHU Sheng jie,SHI Xin.Study on effect of the scavenger for eliminating hydrogen sulfide [J].JOURNAL OF SAFETY SCIENCE AND TECHNOLOGY,2012,8(2):48.

备注/Memo

备注/Memo:
-
更新日期/Last Update: 2012-03-28